| FOR CHEMICAL EMERGENCY CALL:1-800-426-1881 |
SECTION I: PRODUCT AND MANUFACTURE INFORMATION |
Manufacturer:
Wilkins Division of
H.L.
Bouton Co., Inc.
11 Kendrick Road, Wareham,MA,02571
U.S.A., |
|
Information phone: 1-800-426-1881 (business hours)
Fax: 1-508-295-3521
|
Product Name: |
Wilkins LENS Anti-Fog/Anti-Static lens Cleaner |
Product Numbers: |
#503, #508, #516, #597, Towelettes, WK100D, WK1000, #1200, #608, WK500D, ORRAD100, 451U, 551U, WK555 |
DOT Hazard Classification: |
Combustible Liquid (Not regulated in non-bulk containers) |
Date Prepared: January 1, 2004;
Revised January 1, 2007
Prepared by: H.L. Bouton Co. |
|
Section
II Material Identification
and Information |
Ingredient |
CAS No.
|
%
WT/VOL |
OSHA
PEL (ppm) |
OSHA
MG/M3 |
ACGIH
TWA
|
ACGIH
STEL
(ppm) |
VOC*
lbs/gal
@77°F |
Isopropanol Alcohol |
67-63-0 |
15% |
400
|
980 |
400 |
500
|
100%@6.51 LB/GAL |
| Sodium Laureth |
151-21-3 |
5% |
N/E |
N/E |
N/E |
N/E |
N/A |
Section III Physical Data
|
Boiling Point: |
Range 180-212°F. |
Vapor
Pressure: |
@ 20C + 32.8 |
Specific Vapor
Density: |
(Air = 1) 2.1 |
Specific Gravity: |
@20C=0.97 |
| Evaporation Rate: |
(N-Butyl Acetate = 1) 1.25 |
Section IV Fire and Explosion Information |
| Flash
Point: |
106° F Closed Cup
ASTM D3828-02 |
National Fire Protection Association (NFPA) Hazard System
| Health |
Flammability |
Reactivity |
| 1 |
3 |
0 |
|
| Explosive Limits: |
| UFL 12% |
(Upper Flammable Limit) |
| LFL 2.5% |
(Lower Flammable Limit) |
|
| Extinguisher Media:Use water spray, carbon dioxide, dry chemical, alcohol or universal type foams applied by manufacturers recommended techniques. |
| Special
Fire Fighting Procedures:Water may be used to cool containers exposed to heat or flame. |
| Unusual
Fire and Explosion Hazards: Vapors can travel great distances to a source of ignition and flashback. |
Product: Wilkins LENS Anti-Fog/Anti-Static Lens Cleaner
|
Section V
Health Hazard Data
|
| Effects of overexposure: |
| Eyes: |
If splashed in eyes may cause irritation. |
| Skin: |
Prolonged exposure may cause skin irritation, drying or cracking of skin. |
| Inhalation: |
If excessive may cause mild irritation to nose, throat, respiratory system; may experience symptoms of CNS depression (dizziness, nausea, drowsiness) |
| Swallowing: |
Will cause gastrointestinal distress. |
| First Aid: |
If on skin, wash with soap and water. If irritation develops and/or persists, seek medical attention.
If in eyes, flush with water. In case of excessive irritation, consult a physician.
Inhalation: Remove to fresh air. Aid in breathing if necessary and seek medical attention. |
| Ingestion |
If swallowed, drink two glasses of water, induce vomiting, seek medical attention. Never give anything by mouth to an unconscious victim.
If a significant amount has been swallowed, consult a physician. |
| Carcinogens: |
None of the ingredients in this mixture has been identified as carcinogenic or a probable carcinogen by NTP, IARC or OSHA. |
|
Section VI Reactivity
Data
|
| Stability: |
Stable |
| Hazardous
Polymerization: will not occur. |
| Incomparability: Heat, sources of ignition, strong oxidizing agents. |
Section VII Spill or Leak Procedures
|
| Steps to be taken in case material is released or spilled:flush with water or use a non-combustible absorbent. |
| Waste Disposal Method:Dispose of in accordance with Federal, State and Local Regulations. |
Section VIII
- Protective Equipment and Control Measures
|
| Respiratory
Protection: None required for normal use. If threshold limits are exceeded, use NIOSH approved OV Cartridge Respirator. |
| Ventilation: Normal room ventilation. |
| Protection Gloves:
None required for normal use. |
| Eye Protection: None required for normal use. |
| Other
protective Clothing and Equipment: Not required |
Section IX -Special
Precautions
|
Store in cool area away from sources of ignition.
Normal care in handling and storage is all that is required. |
SECTION X: OTHER REGULATORY INFORMATION
|
| Wilkins LENS Anti-Fog/Anti-Static Lens Cleaner is a product used to clean eyeglasses and apply an anti-fog/anti-static coating. |
| Department of Transportation: Not regulated. |
This product does not contain ingredients that are regulated by the following laws or regulations:
| EPA SARA Title III Section 313 |
| Resource Conservation and Recovery Act (RCGA) |
| Proposition 65 - California Safe Drinking Water and Toxic Enforcement Act of 1986 |
| TSCA |
| Workplace Hazardous materials Information System of Canada |
|
Right -To - Know State Lists:
The following chemical is listed on the Massachusetts and New Jersey Lists:
Isopropyl Alcohol CAS#67-63-0 |
| |
The information presented herein has been compiled from sources considered to be dependable and accurate to the best of the sellers knowledge. While the H.L. Bouton Co., Inc. believes the data to be factual and based on the opinions of qualified experts, the data is not taken as warranty or representation for which the H.L. Bouton Co., Inc. assumes legal responsibility. This information is offered solely for your consideration, investigation and verification. |
